Sponsored by Advance Auto Parts

Recently on a trip to the mountains to go hiking, I was traveling through a few friends in a caravan of 3 vehicles. About 10 minutes prior to the trailhead, I looked in my rear-view mirror and also noticed tbelow was currently just one auto behind me rather of two. We made it to the trailhead and also waited, assuming our friends had actually quit for a quick photo shoot or possibly a bathroom break. In the pass we’d quit in to hike, no one had actually any cell phone company, so we had actually trouble reaching our friends. We made a decision to sfinish out a search car, and also as soon as they didn’t rerevolve either, our last vehicle headed back too. We uncovered the remainder of our group parked on the side of the road via the hood open up, looking extremely frustrated and also cold. Their auto had actually overheated as a result of cooling device problems that left them stuck to a bill for a 100-mile tow truck ride. The worst component around the breakdown was it was entirely avoidable if our frifinish had actually taken action a small sooner.

You are watching: Why is my car overheating with a new thermostat

If your car or truck is overheating on a constant basis, it’s essential for you to acquire the problem checked appropriate away so you don’t get stranded miles from house and also stuck with an expensive tow bill. The engine in your car is additionally designed to operate under an extremely specific set of parameters. One of the parameters is the operating temperature. Even if the temperature gauge doesn’t reach the height, you can still be doing irreversible damages to your engine, costing you even more money in repairs and possibly damaging your engine past the ability to repair. In order to diagnose your overheating problems, let’s look at all the possible factors a auto might overheat:

Possible causes of overheating:

Low coolantClogged radiator (internally or externally)Broken thermostatClogged or fowled coolant passagesImappropriate air/fuel mixture or ignition timing

If your automobile has an externally clogged radiator, you can commonly watch it from the front of your vehicle. Look behind the grill or bumper for the fins of the radiator. If tbelow are leaves, dirt or debris blocking air from flowing over the fins of your radiator, it have the right to cause your car to overwarmth. Rerelocating the blockage either by washing or brushing away the debris can deal with your overheating problem. You need to be exceptionally mindful while rerelocating outside blockage from the radiator to prevent both damaging the delicate radiator fins and also from injuring your hands on the sharp edges. You have the right to inspect for internal radiator clogs by opening the radiator cap once the engine is cool. Check the fluid and the radiator for a brown color, or suspfinished contaminates in the coolant. If you have an infrared thermometer, you can additionally examine the temperatures at different points in the radiator while the automobile is running and warm. They have to drop uniformly as coolant travels from the optimal hose of the radiator diagonally to the bottom hose. If tbelow are places wright here the temperature is the exact same, or drops significantly, you more than likely have actually an interior clog. The finest point to do in this instance is a full cooling device flush using BlueDevil Radiator Flush to clean out the clog and include fresh coolant to your clean system.

A broken thermostat deserve to additionally cause your automobile to overheat. The thermostat in your engine controls the circulation of coolant. When the engine is cold, the thermostat closes. This permits coolant to circulate via the engine block and also the heater core in your auto, but not the radiator. As the coolant reaches operating temperature, the thermostat opens up to permit some of the coolant to ow through the radiator and be cooled. This keeps the coolant in your engine at a particular temperature designed for finest procedure. If the thermostat falls short, it can stick shut. This will certainly save the coolant from ever before entering the radiator and your engine to overwarmth. You can check this by checking the temperature of the top radiator hose. If it is warm near the radiator after you have pushed your car, then coolant is owing with it. If it is still cold, you might have a broken thermostat and also must remove the thermostat and also test it. Be careful as soon as checking the top radiator hose temperature as it can be warm sufficient to burn. A thermometer is finest for this examine.


You can check for clogged or fouled coolant passeras in the same method you would certainly inspect for an interior radiator clog and also additionally resolve that problem by utilizing BlueDevil Radiator Flush.

An imcorrect air-fuel mixture have the right to additionally cause on overheating condition. A lean condition in the time of burning will reason a hotter than usual combustion procedure, producing excess warmth and also feasible overheating. Similarly, late ignition timing can cause excess warm in the burning procedure. If your automobile is carbureted, try adjusting the carburetor to run an additional action or two well-off. Fuel injected cars hardly ever run lean, but you may take into consideration checking your fuel system components favor the filter, injectors and O2 sensor. If your vehicle is old enough to have actually a distributor, you have the right to check and also readjust your ignition timing to manufacturing facility specifications, but even on older cars this difficulty rarely exists.

The the majority of likely cause of an engine overheating is a low coolant level. Your cooling system has actually many connections and components that are prone to faiattract even under normal conditions. Tbelow are multiple gaskets, hoses and seals that might fail in the cooling mechanism, resulting in a leak. If you notification puddles of coolant on the ground, you most likely have an external coolant leak from a hose or the radiator. If you alert coolant inside your auto, you likely have actually a broken heater core. If you notification white smoke coming from your exhaust, or bubbles in your coolant overow tank, it is possible that you have actually a leaking head gasket. For any type of of these leaks you can usage BlueDevil Head Gasket Sealer to seal the leak. BlueDevil Products are guaranteed to seal your leak permanently and have actually no particulate issue to clog or foul any kind of components in your cooling mechanism.

See more: Just Something To Take The Edge Off, Take The Edge Off


You have the right to purchase BlueDevil Head Gasket Sealer here.

You have the right to additionally purchase every one of the guaranteed BlueDevil Products at your regional Advance Auto Parts